General • Inspections

Agility™ Centrifugal Water-Cooled Chiller - Annual Maintenance

Annual maintenance is a simple and cost-effective way to ensure your HVAC system is running at peak efficiency and to catch problems before they get serious.

MaintainX

08/10/2022

Agility™ Centrifugal Water-Cooled Chiller - Annual Maintenance

Annual maintenance is a simple and cost-effective way to ensure your HVAC system is running at peak efficiency and to catch problems before they get serious.

Contact your local Trane Service Agency to shut down the chiller once each year and perform the following:

Manual Link

Perform all weekly and monthly maintenance procedures.
Leak check the chiller, inspect safety controls, and inspect electrical components, such as magnetic bearing controller and Uninterruptible Power Supply (UPS).
Inspect all piping components for leakage and/or damage. Clean out any in-line strainers.
Clean and repaint any areas that show signs of corrosion.
Inspect vent piping of all relief valves for presence of refrigerant to detect improperly sealed relief valves.
Inspect the condenser tubes for fouling. Clean if necessary; refer to “Cleaning the Condenser,” p. 63.
Visually inspect waterbox hinges to ensure that hinges have not been damaged or altered.

Note: If, after 10 years, the battery has not been replaced, Trane recommends replacing the battery.

Source: MaintainX (Community Member)

Contact your local Trane Service Agency to shut down the chiller once each year and perform the following:

Perform all weekly and monthly maintenance procedures.

Leak check the chiller, inspect safety controls, and inspect electrical components, such as magnetic bearing controller and Uninterruptible Power Supply (UPS).

Inspect all piping components for leakage and/or damage. Clean out any in-line strainers.

Clean and repaint any areas that show signs of corrosion.

Inspect vent piping of all relief valves for presence of refrigerant to detect improperly sealed relief valves.

Inspect the condenser tubes for fouling. Clean if necessary; refer to “Cleaning the Condenser,” p. 63.

Visually inspect waterbox hinges to ensure that hinges have not been damaged or altered.

Note: If, after 10 years, the battery has not been replaced, Trane recommends replacing the battery.